Dacflyer

thanks.. But I like the simple controls, newer radios have too many buttons or menus you must traverse. I know my radio, I can do most what ever without looking at it.. I use mostly the BT or my AUX input ( XM Radio connected to it ) Is everything contained in the radio ? the voice command thing ? the USB AUX.... or is that in another module ? Because when i looked, the harness goes off into the abyss under the dash.. If there is another module, i'd zero in on that more than the radio itself.. I know I could get something more modern, but then it's not what i want.. And i don't use a smart phone either. only because of data rates.

My van has the Sync radio ( green screen ) Picture included in post.. a few days ago it got to where the AUX input mode was not functioning as normal..It would start with FM radio.. you'd have to push AUX to get it back to that mode. this morning i start the van and it's only working in AM or Fm mode, and at times if you flip from FM1 to FM2, 1 or the other would tune to FM, but it sounded like AM stations. the steering wheel control that you press to get the voice to speak ( Please Say A Command ) she's quit as well.. I mainly use the AUX input connected to my XM radio.. I have isolated to see if it was the XM radio or the cable going to the radio.. all is good, The SYNC is what is the issue. It is as if the radio is ok,, but the SYNC part had died. What to do ? Suggestions ? I am experienced in electronics etc.. So I'm open to suggestions.. Has anyone else had this issue ?

I have a 2013 connect, the van takes for ever to heat up. i can start it in the morning, and in about 10-15 min the temp gauge is in the normal center position, but the heat is luke warm, I can drive it about 10 min to work, and the heat is a bit warmer, but still not as it should be. I can park it for 5 min and then drive it again and the heat is pleasant by then. Is this the nature of the system ? I've had smaller cars ( Geo Metro 3 cyl ) that heated up way faster. At work we had a 2015 F550 truck that had weak heat as well, but if you reved the engine hard 1 or 2 times it heated up fine, but if you were at a stop light or such, the heat got cold again.. The dealership futzed with it over a year before they got it fixed I never did find out what it'd issue was. Any tips i can try to get the heat working in my van better? it's only got 42K on it, and all fluids are up to level and clean still. so i highly doubt there's any clog in the heater core. I'm thinking it''s either bad circulation or a air bubble in the system, if so, how do i burp it out ?

I found out, that I do have defrost mirrors, but there's no indicator that lights up for them, and the switch is connected in with the rear window defroster switch. I just had to wait til it was cold enough to find out..

Sorry i never got a notification for this. Thanks for the information. Removing the IC doesn't look as hard as I thought. I'll keep ya posted on what i find.. I'm guessing the lights in the IC are led.

I'm sure it''s cheap materials and I'm sure they are the OEM brakes since the miles are so low on this van. Was just wondering if the recall would still be valid.. save some bucks. I'm going to get it fixed either way. but if the dealer will cover it then i'll do it. I guess i'll just have to call em up and see..

oh, ok, perhaps it is fuel related.. I had a Geo Metro that had a fuel pump go bad. I got a replacement pump and a filter. ( little did I know i should have gotten a new sock as well to go on the pump) I replaced this and all was fine til I was over 2 hrs away from home and the car started to loose power. Fuel presser was down to nothing. I though the new pump went bad already. Later i learned....ALWAYS New Pump, New sock filter. I was mad that the parts guy didn't sell me one.. Had to drop the tank all over again. not sure if you have a bad filter issue or dirty fuel pump filter ( sock ) maybe something gives you a clue. Good luck

I have checked the drums ( On both sides ) the shoes and drums are silky smooth, plenty of pad on the shoes, no gouges or nothing,, they look perfect.. I drove a large line truck at work for years ( yes it was a ford also ) and the brakes would squeel like hell til they got warm. some days i rode the brakes til they got warm, then they were good the rest of the day. The mechanic said they were fine..just how they are.. But this shouldn't be the case in a passenger vehicle. Maybe it's the quality of the shoes ?

did you ever find a solution to this ? I am not too familiar with the engine on this vehicle, but it may be ignition related. i had a vehicle that would crank and run great, but once it got warm it sputtered and died. there's only a few sensors are are critical to engine running. other sensors will allow the car to run in limp mode, but the crank sensor and cam sensors are critical. i thought the car had a bad crank sensor, but that wasn't it. it turned out to be a bad distributor cap. newer engines are lacking distributors, but you might have a ignition coil going bad, or ignition related issue. Just a thought.

I have a 2013 with this issue. brakes on the right rear make that horrible metal on metal sound when they are cold, but after braking a few times they are warm enough that they stop, but you can also hear the mechanics of the brakes squeek as you let off the brakes. Would this recall still be honored this many years later ? the van has barely 38K on it.. it had 32K on it when i bought it..

where exactly is this wire ?

My 2013 TC XLT has the defrost icons on the mirrors but they never light up. Does my van have this option ? If it does, then when does it activate ? It does not seem to work with the defrost button for the back windows. there's been frosty weather many times already ( below freezing ) If the van has this,,are they automatic ? I'm guessing that if the icon is on the mirror, then the heaters are there also,, So maybe there's a relay or module i can just add in somewhere ?

I get fist fulls of relays at the junk yard, i pay a $2.00 entry fee, so i grab things that will never be bought ( bulbs , fuzes and repays )

does anyone know if this module is a stand alone unit or does it integrate with the cars computer? I'm asking because i am thinking to add more sensors for side of vehicle warning ( if something is too close to the sides ) These would also be handy for a front bumper as well when parking in tight spaces.

I have a 2013 Transit Connect XLT The key FOB for my van doesn't always want to lock when i use it, I read somewhere that the body and the metal window screens will shield the signal. My van has the screens in the back and sides. I have to practically hold the fob to the window to get the van to lock sometimes. Does anyone know where this receiving antenna is located in the van? I'm thinking to find a way to make reception better. (Yes i do have electronic experience ) Other question is..under my rear view mirror , on the glass part there is an area that looks like there might be a electronic module. Does anyone know what it is ?